Don't miss this hot spot

Steve Hirano, Editor/Associate Publisher
Posted on April 1, 2007

You’ll note that most of this issue is devoted to the bus garage, which makes sense since this is our maintenance issue. In pupil transportation, however, maintenance isn’t simply about engines, wrenches and oil-change intervals; it’s about safety. Everything that goes on in the garage should be focused on maximizing the chances that schoolchildren will be transported safely every day.

So, let’s consider this our maintenance/safety issue. Which brings me to a maintenance concern that is particularly urgent in the wake of a recent report by federal safety investigators. On Feb. 21, the National Transportation Safety Board (NTSB) found that “insufficient lubrication” of a rear wheel bearing assembly was the principal cause of a fatal motorcoach fire on Sept. 23, 2005.

The coach, operated by Global Limo of Pharr, Texas, was helping to evacuate 44 assisted-living facility residents and nursing staff from Bellaire, Texas, to Dallas as Hurricane Rita approached. As the coach neared Wilmer, Texas, a motorist signaled the driver that the bus’ right rear tire hub was glowing red. The driver stopped the coach and began to evacuate the passengers. Before all of the passengers could be removed, the bus interior filled with smoke and fire, causing the deaths of 23 people.

Unnecessary losses
This catastrophe could have been avoided. According to NTSB investigators, Global Limo had no maintenance program in place, setting up a situation in which a wheel bearing unit lost its lubrication and caused a fatal fire.

How is that possible? How could a coach company that’s responsible for the lives of its customers not have a vehicle maintenance program? Not have any maintenance records of any sort? Not require its drivers to perform pre- and post-trip inspections? These are questions that judges and juries will likely sort through in the coming months and years. The point for school bus operators is that they should never get complacent about their maintenance programs. The apparent maintenance shortcomings of Global Limo become obvious when circumstances cram so much tragedy into a single incident.

But how long can you go before your luck begins to catch up with you? Quite a long way, actually. You shouldn’t assume that hundreds of thousands or even millions of miles of safe travel is an indication that you’ve got a top-notch garage operation. It could just mean that you’re lucky.

When your luck runs out
Maybe Global Limo was lucky too — until that horrific day in 2005. You shouldn’t rely on luck. If your maintenance program is not as good as you can possibly make it, take the steps to make it better. Here are a few not-so-novel ideas for improvement, some of which I’ve gleaned from our annual Top 10 Maintenance Programs articles:


  • Emphasize training. It’s hard to take time to sharpen the saw when there are so many trees to be cut down, but it pays dividends in the long run. Send your technicians to local, regional or state training workshops.


  • Get organized. An effective garage finds ways to maximize its resources through job tracking and analysis of repair work.


  • Talk it out. Good communication, up and down the org chart, is essential. Make sure everyone is free to share their concerns and suggest improvements.


  • Get your bearings. Per the NTSB, emphasize the importance of wheel-bearing lubrication, specifically stressing that daily inspection of hub oil levels and wheel seals is vital.


  • Comments ( 0 )
    More Stories
    Auto Safety House, the Thomas Built Buses dealer for Arizona, will operate as a brand of W.W. Williams. Seen here is a W.W. Williams service center.

    W.W. Williams Acquires Auto Safety House

    Auto Safety House, the Thomas Built Buses dealership for Arizona, will operate as a brand under the ownership of W.W. Williams, a provider of repair services and products.


    Portable Child Restraint

    HSM Transportation Solutions’ C.E. White Portable Child Restraint for school buses, a five-point restraint system, is designed to accommodate children weighing 20 to 90 pounds and up to 57 inches in height.


    2-Camera System

    The DS2 is a two-camera vehicle event recording system that combines high-definition video recording, fleet telematics, and vehicle operating data on one screen for better incident review and driver coaching.

    Four dealers won IC Bus’ 2016 Diamond Premier Dealer award, while 11 won the Diamond Dealer award.

    IC Bus Honors Top Dealers for 2016

    Four dealers win the bus manufacturer’s Diamond Premier Dealer award, while 11 win the Diamond Dealer award. IC Bus also bestows its Pursuit of Excellence award.


    VIDEO: BusWise Efficiency Features

    BusWise Technologies for Thomas Built Buses' Saf-T-Liner C2 school bus offers features that can help in boosting efficiency, such as tracking location, speed, and fuel consumption.

    Be the First to Know

    Get the latest news and most popular articles from SBF delivered straight to your inbox. Stay on top of the school bus industry and don't miss a thing!